The main pump has a low pressure side and a high pressure side. The low pressure side of the pump is capable of sucking diesel from the tank via the diesel filter. The first thing you must do is to change the diesel filter. If your glow plug light is flashing you need to connect a fault code reader and find out the exact nature of the problem. June 2021 – Fuel pump ‘examined’ by ‘specialist’ and pronounced ‘in good order’ Seven months of further diagnostics (involving hours of effort and expensive labour) following advice found here and on other forums to no avail: February 2022 – Fuel pump examined by a different ‘specialist’ and found to be faulty. Ford Mondeo Mk3 (2000 - 2007) Diesel Engines (Mondeo Mk3) So I called it there as being the fuel lift pump (located near the rear rhs wheel). Ok so I am new to this site, so I am hoping to get the help I need. I have a 2005 mondeo tdci and was driving along and suddenly the engine cut out. After a tow home I checked out the top half of the engine and the cam carrier was smashed. I removed the timing chain cover to discover the timing had slipped at least two teeth. 3036 posts · Joined 2009. #3 · Sep 21, 2013. Syphon it from the tank. Pop a bit of hosepipe down the filler pipe and drain it into cans. Cut one end at an angle and if you slowly rotate the pipe it will go into the tank then suck on it to get the fuel flowing. 2004 Hatchback 130 TDCI Inkblue 564.000 Miles. (Retired) Have a no start issue, this frame mounted fuel pump could be your problem!! What is up family!! Here we wanted to show you all what you might run into while UkjW41G. The job of a lift pump is to supply low pressure fuel (from the tank) to the injection pump on the engine. Most lift pumps, aftermarket or OEM, provide between 8-to-15 psi worth of supply pressure (aside from the 7.3L, 6.0L and 6.7L Power Stroke engines, which call for 45-to-65 psi). The FlowMax pump’s volume is 2.5 times greater than the stock pump’s volume at a higher pressure (Ford’s 6.4L lift pump flows 60 gph at 1gpm while BD’s FlowMax delivers 150 gph at 2.5 gpm Ford Mondeo III (2000 - 2007) - replacement fuel pumps. Hi folks, just joined the forum though have been reading HJ's page in the Telegraph motoring section for years, and naturally came straight here with my problem. Anyway, I have a 2002 Modeo 2L tdci. Bought it with 124K on the clock and have owned it for 30 months and loved it until recently. This fault here can be caused by a fault with the fuel injection pump itself.I have seen the fuel injection pumps act up like this here in the past before needing replaced.I would have the fuel rail pressure tested to see if for sure this is the cause here.I would also have the fault codes checked with a fully compatible scan tool to see what Rated at 400 psi and ok for diesel fuel: 3/8” hoses: 2 required 2 “ (fuel tank to pump & low pressure feed from filter to pump) 1 required 2 7/8” (fuel pump outlet to filter) 5/16” hoses: 1 required 1 ¾” (FPR tubing) 1 required 5” (if replacing drain hose) Fuel Filter Heater: Ford F5TZ-9J294-A International 1825186C91

ford mondeo mk3 diesel fuel lift pump